Utilization of Sewage Sludge-Derived Pyrogenic Material as a Promising Soil Amendment
Frišták, Vladimír (Trnava University in Trnava. Department of Chemistry)
Pipíška, Martin (Trnava University in Trnava. Department of Chemistry)
Koperová, Dominika (Trnava University in Trnava. Department of Chemistry)
Jagerhofer, Reinhard (Austrian Institute of Technology GmbH. Energy Department)
Soja, Gerhard (Austrian Institute of Technology GmbH. Energy Department)
Bell, Stephen Mackenzie (Universitat Autònoma de Barcelona. Institut de Ciència i Tecnologia Ambientals)

Fecha:	2022
Resumen:	The use of advanced treatment technologies such as pyrolysis and carbonization of bio-waste materials has the promise to develop coupled solutions for organic C and P problems in the future of food processing. Sewage sludge-derived pyrogenic materials that are applied to the soil system contain notable levels of P (1-20%). However, only a small portion of total phosphorus is available for plants. Therefore, our study assessed the pretreatment of sewage sludge with Na2CO3 and subsequent pyrolysis at 400 °C and 500 °C for the production of MPCM400 and MPCM500 as potential alternatives for inorganic P fertilizers. Non-pretreated sewage sludge-derived pyrogenic carbonaceous materials (PCM400 and PCM500) were produced as controls. The derived materials obtained by slow pyrolysis at a residence time of 120 min and pyrolysis temperatures of 400 °C and 500 °C, were analyzed by determination of electrical conductivity (EC), pH, elemental analysis of total C, H, N, scanning electron microscopy (SEM) and total concentrations of P, Cd, Fe, Pb and Zn. PCM400, PCM500, MPCM400 and MPCM500 were characterized by analysis of total 16 US-EPA (U. S. Environmental Protection Agency) PAHs by a toluene extraction procedure. Additionally, PCM400, PCM500, MPCM400 and MPCM500 were tested by a germination test with cress seeds (Lepidium sativum L. ) and a short-term rye seedling test. Total C concentrations were raised in the order: MPCM500 < MPCM400 < PCM500 < PCM500. Concentration of Σ16 US-EPA PAHs was almost five times higher at PCM500 (21. 87 mg/kg) compared to PCM400 (4. 38 mg/kg) and three times higher at MPCM500 (23. 12 mg/kg) compared to MPCM400 (7. 55 mg/kg) with a dominant role of two and three-ring aromatic structures. Total P-concentrations in rye biomass increased in the order for the controls: (2. 43 ± 0. 95 mg/g) < PCM400 (3. 57 ± 0. 27 mg/g) < PCM500 (4. 04 ± 0. 24 mg/g) < MPCM400 (5. 23 ± 0. 09 mg/g) < MPCM500 (5. 57 ± 0. 70 mg/g) < IF (7. 53 ± 2. 65 mg/g). Obtained results showed that pyrolysis materials produced from sewage sludge represent a potential alternative of conventional P inorganic fertilizers and organic C suppliers.
Nota:	Unidad de excelencia María de Maeztu CEX2019-000940-M
Derechos:	Aquest document està subjecte a una llicència d'ús Creative Commons. Es permet la reproducció total o parcial, la distribució, la comunicació pública de l'obra i la creació d'obres derivades, fins i tot amb finalitats comercials, sempre i quan es reconegui l'autoria de l'obra original.
Lengua:	Anglès
Documento:	Article ; Versió publicada
Materia:	Sewage sludge ; Pyrolysis ; Phosphorus ; Na2CO3 ; Feedstock pretreatment
Publicado en:	Agriculture, Vol. 12, Issue 3 (March 2022) , art. 360, ISSN 2077-0472

DOI: 10.3390/agriculture12030360

13 p, 2.9 MB

El registro aparece en las colecciones:
Documentos de investigación > Documentos de los grupos de investigación de la UAB > Centros y grupos de investigación (producción científica) > Ciencias > Institut de Ciència i Tecnologia Ambientals (ICTA)
Artículos > Artículos publicados